KRYLON INDUSTRIAL -- RUST TOUGH-3 COLD GALVANIZE, 00859  -- 8010-00N049366
<pre>=====================  Product Identification  =====================

Product ID:RUST TOUGH-3 COLD GALVANIZE, 00859
MSDS Date:02/20/1993
FSC:8010
NIIN:00N049366
=== Responsible Party ===
Company Name:KRYLON INDUSTRIAL
Address:6830 COCHRAN RD
City:SOLON
State:OH
ZIP:44139
Country:US
Info Phone Num:800-247-3266
Emergency Phone Num:216-292-7400
CAGE:DO934
=== Contractor Identification ===
Company Name:KRYLON INDUSTRIAL
Address:6830 COCHRAN ROAD
City:SOLON
State:OH
ZIP:44139
Country:US
Phone:800-247-3266
CAGE:DO934
Company Name:SHERWIN-WILLIAMS CO THE
Address:101 PROSPECT AVE NW
Box:City:CLEVELAND
State:OH
ZIP:44115-1042
Country:US
Phone:800-251-2486/216-566-2242
CAGE:54636

=============  Composition/Information on Ingredients  =============

Ingred Name:ING 7: PROC. CONTENTS UNDER PRESS. DO NOT
    PUNCTURE/INCIN/EXPOSE TO TEMP > 120F. HEAT FROM SUNLIGHT,
    RADIATORS, (ING 9)
RTECS #:9999999ZZ

Ingred Name:ING 8:STOVES, HOT WATER & OTHER HEAT SOURCES COULD CAUSE
    CNTNR TO BURST. DO NOT TAKE INTERNALLY. KEEP OUT OF (ING 10)
RTECS #:9999999ZZ

Ingred Name:ING 09: THE REACH OF CHILDREN.
RTECS #:9999999ZZ

Ingred Name:OTHER PREC: MAY BE PRESENT @ HAZ LEVELS ONLY DURING
    SANDING/ABRADING OF DRIED FILM. IF NO SPECIFIC DUSTS ARE (ING 12)
RTECS #:9999999ZZ
Other REC Limits:NONE RECOMMENDED

Ingred Name:ING 11: LISTED, APPLIC LIM ARE ACGIH TLV 10 MG/M3 (TDUST),
    OSHA PEL 15 MG/M3 (TDUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ

Ingred Name:RESP PROT: FOR PROT AGAINST NON-VOLAT MATLS LISTED IN
    INGREDS.
RTECS #:9999999ZZ

Ingred Name:PROPANE; (PROPELLANT)   VP: 760
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT

Ingred Name:VM&P NAPTHA   VP: 12
CAS:64742-89-8
Fraction by Wt: 1%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM

Ingred Name:XYLENE (SARA III)	VP: 5.9
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10%
OSHA PEL:100 PPM; 150 STEL
ACGIH TLV:100 PPM; 150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (SARA III)   VP: 70
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 34%
OSHA PEL:200 PPM; 300 STEL
ACGIH TLV:200 PPM; 300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:ZINC  (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 38%
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:VOLATILE ORGANIC COMPOUNDS: 60% BY WEIGHT PER BAAQMD RULE
    49
RTECS #:9999999VO
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:SUPDAT: ELEC TOOLS & APPLIANCES & ANY OTHER SOURCES OF
    IGNIT. CONSULT NFPA CODE. USE APPRVD BONDING & GROUNDING (ING 8)
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & RESP SYS.
    MAY CAUSE NERVOUS SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
    POSS DEATH. HDCH, DIZZ, NAUS & LOSS OF COORDINATION ARE INDICATIONS
    OF EXCESS EXPOS TO VAP/SPR AY MISTS. REDNESS & ITCHING/BURNING
    SENSATION MAY INDICATE EYE/EXCESS SKIN EXPOS. CHRONIC: METHYL (EFTS
    OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: ETHYL KETONE MAY INCREASE THE NERVOUS
    SYS EFTS OF OTHER SOLV. PRLNG OVEREXP TO SOLV MAY CAUSE ADVERSE
    EFTS TO LIVER, URINARY, BLOOD-FORMING, CARDIOVASCULAR &
    REPRODUCTIVE SYSTEM. REPORTS HAV E ASSOC RPTD & PRLNG OVEREXP TO
    SOLV W/PERM BRAIN & NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.

=======================  First Aid Measures  =======================

First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
    QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP & WATER.
    REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES: FLUSH
    EYES WITH LA RGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET
    MEDICAL ATTENTION. INGEST: GET MEDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:0.9%
Upper Limits:13.1%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
    WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZ PREF. WATER
    MAY BE USED TO COOL CLSD CNTRNS (SUPDAT)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPK & OPEN
    FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO EXTREME HEAT.
    APPLICATN TO HOT SURF REQS SPECIAL PREC. DURING (SUPDAT)

==================  Accidental Release Measures  ==================

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
    REMOVE WITH INERT ABOSRBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:EXTREMELY FLAMM. KEEP AWAY FROM HEAT,
    SPKS & OPEN FLAME. VAPS WILL ACCUM READILY & MAY IGNITE EXPLO.
    DURING USE & UNTIL ALL VAPS GONE: KEEP (SUPDAT)
Other Precautions:INTENTIONAL MISUSE BY DELIB CONC & INHALING CONTENTS
    CAN BE HARMFUL/FATAL. USE ONLY W/ADEQ VENT. AVOID BRTHG VAP & SPRAY
    MIST. AVOID CNTCT W/SKIN & EYES. COATINGS MAY CNTN MATLS CLASSIFIED
    AS PARTICUL ATES (LISTED AS DUST) WHICH  (ING 11)

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF EXPOS CANNOT BE CONTROLLED BELOW APPLIC LIM
    BY VENT, WEAR PROPERLY FITTED ORG VAP/PARTICULATE RESP APPRVD BY
    NIOSH/MSHA. WHEN SANDING, WIREBRUSHING, ABRADING, BURNING/WELDING
    DRIED FILM, USE PARTIC ULATE RESP APPRVD BY NIOSH/MSHA (ING 13)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS MAINTAINED
    BELOW APPLIC LIM. REFER TO OSHA STDS 1910.94,1910.107,1910.108.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC: TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLOS WHEN
    EXPOSED TO EXTREME HEAT. EXPLO HAZ: EMER CNDTNS OVEREXP TO DECOMP
    PRODS MAY CAUSE HLTH HAZ. SYMP MAY NOT BE IMMED APPARENT. OBTAIN 
    MED ATTN. HNDLG/STOR PREC: AREA VENT. DO NOT SMOKE. EXTING ALL
    FLAMES, PILOT LIGHTS & HEATERS. TURN OFF STOVES, (ING 7)

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:<395F,<202C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate &amp; Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
    MONOXIDE, OXIDES OF METALS LISTED IN INGREDIENTS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:WASTE MAY BE HAZ AS DEFINED UNDER RCRA 40CFR
    261. WASTE MUST BE TESTED FOR IGNIT TO DETERM APPLIC EPA HAZ WASTE
    #. MAY ALSO REQ TESTING FOR EXTRACTIBILITY. DO NOT INCIN. DEPRESS
    CNTNR. DISPOSE OF I/A/ W FEDERAL, STATE & LOCAL REGS
    REGARDINGPOLLUTION.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.